A clutch is a wear item so it's only a matter of time before we each need to replace one. I replaced mine at 80,000 miles because I was in there to replace a leaking IMS cover seal. As it turned out, my original clutch was still in excellent condition. But there's nothing like the bite of a new clutch, and my leak repair required removal of the clutch, so replacement required nothing more than ordering parts. Because there is so much labor involved, it would have been senseless for me not to...
63 Comments

The IMS seems to be a real pain in the neck for us Porsche owners. Fortunately us Cayman owners are not very likely to experience an IMS bearing failure, but I have seen a number of members (including myself) develop a leak around the IMS cover. The seal is inexpensive, but the labor to reach it is significant and many specialty tools are required. I suspect that there are only a handful of members here who might attempt this repair themselves, but I thought it would be good to document...
58 Comments

Replacing the Cayman air cleaner is pretty straightforward, and would be extremely easy except for the fact that the clearances are very tight. Some people refer to the air cleaner as an air filter, the engine air filter, etc., I would consider all to be correct. Why? The air cleaner is a scheduled maintenance item. Some owners in dusty or dirty environments will decide to replace this item on an accelerated schedule. Prerequisite- Remove Upper Engine Cover (link) Tools-
57 Comments

Replacing the Cabin Air Filter (also referred to as the Pollen Filter) is possibly the easiest maintenance task to perform on a Cayman. I'll demonstrate this task on my 2007 Cayman S. There are aftermarket filters available, but I like to use OE parts for my Porsche. The part number of the factory Porsche filter is 997.571.229.01. It's available at any Porsche parts department. I usually keep one on hand. Once you've obtained an OE filter or suitable replacement, you're ready to...
51 Comments

Car batteries have a limited life span and will someday need to be replaced in every Cayman. There are many points to consider when choosing a replacement battery and when considering whether or not you'd like to change it yourself. You may want to search our forums for discussions about batteries before you decide on a battery and/or start your replacement. The battery replacement procedure for a Cayman is not much different than that used in other cars, but different enough that I think...
51 Comments

Article Addendum, August 14th, 2011. ATTENTION: After 25,000 miles with this product on my car I have experienced a serious problem with my original exhaust components. Please see this thread for more information. Based on these developements, I advise the addition of a stress relieving flex joint to the downpipes of this system. 3 You should see some of the looks I get when I tell people that I've changed the exhaust system on my two year old Porsche seven times since I bought it. I...
49 Comments

In Part 1, I covered some of the basic functions that can be performed using the Enthusiast version of the Durametric cable. In this tutorial, I will discuss some of the more advanced uses of the cable, including some Coding functions for those who purchase or borrow the Professional cable. NOTE: Some some of these functions, particularly Activations and Coding could result in damage to your vehicle, as well as disabling some of the normal safety functions of your car. You undertake these...
49 Comments

Removing the Exhaust System (Catback) 1 Torque Values Fastener LocationDescriptionTool SizeTorque ValueExhaust Flange NutsM8 Nut (x6) (Replace with Stainless Steel)13mm Socket17 ft.lb.Rear Exhaust to Hanger8mm Bolts and M8 Lock Nuts (x4)13mm Socket17 ft.lb.Exhaust Hanger Clamps8mm Bolts and M8 Lock Nuts (x8)13mm Socket17 ft.lb. 1 1). Place wheel chocks in front of and behind each front wheel. 2). Jack up both the right and left rear wheels of the car. Use jack stands to ensure...
47 Comments

987.1 Cayman LED Running Lights / Radiator Protectors by Mike Santowasso, Cayman Register member "Speedy" Background Several weeks ago, I threw my name in the hat for a chance to take part in a PCA sponsored project to create a “how to” documentary on the installation of a set of LED Spars on a Cayman. The LED spars can be purchased for $399 (and would be provided to me for free). They were designed and produced by PCA member and Cayman enthusiast =11967"]Joseph DeSimone. They’re a...
46 Comments

This is a very basic DIY and I hope to contribute more as I get to know my new Cayman over the years. But chalk it up as the first wrenching done on my new car. (I love working on cars) I wanted the safest method of getting the stickers off without trashing my brand new CR’s sun visors. So, this DIY is a summation of several DIYs that I read on the topic, that works, at least, for gen 2 vinyl Porsche sun visors. I read about the sun visor sticker removal on another forum. Ever since it...
44 Comments